DodgeRam.org
>
Main
>
Dave's Ram
> Repair Log
Fritz's Ram Repair Log
Things that have broken on my truck!
REPAIR LOG
DATE -----ODO---HOURS-REPAIR
12/16/93 - 000017 - xxxx - New Truck
01/07/94 - 001194 - 0000 - ADD Hour Meter
01/08/94 - 001284 - 0003 - High Idle speed, Adjust Throttle linkage
02/10/94 - 002130 - 0032 - Poor Steering, Adjust Toe-in
06/28/94 - 006115 - 0151 - Steering wanders, Rotate tires
12/21/94 - 011035 - 0295 - Steering Wanders, Align front end
12/24/94 - 011148 - 0300 - Plugs installed in back of steering wheel - RECALL NUMBER 627
01/11/95 - 011813 - 0322 - LR brake grabbing, Replace axle seals and brake shoes
01/11/95 - 011813 - 0322 - Steering doesn't center, Adjust steering gear preload
01/26/95 - 012046 - 0332 - Steering doesn't center, Check steering gear, order replacement
02/10/95 - 012448 - 0350 - Steering doesn't center, Replace Steering gear, Align front end
04/03/95 - 013321 - 0380 - No Tach, charge or cruise, Replace engine speed sensor
05/21/95 - 015151 - 0427 - Replace passenger seat belt cinch bar - RECALL
11/08/95 - 019609 - 0563 - Power steering fluid leak, Tighten fittings
11/08/95 - 019609 - 0563 - Replace back steering wheel cover - RECALL
03/14/96 - 022249 - 0638 - Steering poor and wheel doesn't return to center, Alignment failed
03/27/96 - 022336 - 0641 - Alignment not possible, replace all ball joints and track bar
04/01/96 - 022459 - 0644 - Front end thumping - replace sway bar end links
06/06/96 - 029215 - 0796 - repair windshield stone chip
07/29/96 - 035125 - 0923 - Exhaust rattle, tighten clamp - driveway repair
07/30/96 - 035153 - 0934 - Slight Steering pull - Adjust front toe-in, caster and camber OK
- 036000 - End of Warranty
11/11/96 - 037047 - 0989 - Replace frayed throttle cable
11/11/96 - 037047 - 0989 - ABS and Brake warning lamps lit, Fault code 78 cleared
11/27/96 - 037991 - 1010 - Replace wiper blades
02/03/97 - 039237 - 1051 - Brake booster fails in cold weather, Replace check valve
NOTE: vacuum problem was later found to be in Pacbrake cylinder
02/21/97 - 039440 - 1059 - Steering shaft sleeve installed - RECALL NUMBER 709
06/01/97 - 041607 - 1137 - Remove Dead Preluber pump (installed 02/19/94 - 003152 - 0072)
09/27/97 - 044907 - 1235 - Repair preluber, re-install
11/18/97 - 050485 - 1339 - Replace leaking PacBrake Cylinder (warranty)
12-26-97 - 051626 - 1365 - Replace right headlight bulb
04-28-98 - 053207 - 1414 - Replace leaking fuel return hose (behind fuel filter)
12-19-98 - 065405 - 1686 - Replace frayed throttle cable with new design
06-03-99 - 068684 - 1770 - Replace throttle control rod end (LH thread)
06-03-99 - 068684 - 1739 - Bend new ends on broken throttle return springs
07-31-99 - 069444 - 1789 - Replace throttle control rod end (RH thread)
07-31-99 - 069444 - 1789 - Steering shaft clunk, install Borgeson shaft
08-10-99 - 069444 - 1789 - Front end shake, install DT track bar
09-09-99 - 070673 - 1821 - Replace sticking PacBrake switch with new design
11-06-99 - 072012 - 1848 - Replace blown stabilizer bar end links
03/25/00 - 073519 - 1894 - Replace jammed parking brake pedal mechanism
05/14/00 - 073600 - 1898 - Set timing and adjust valves. Timing at 10 deg - moved to 13.5
07/25/00 - - Recall: Spring tower supports
07/25/00 - - Recall: Heater fan wiring
TOP
HOME
